Home » How to » Battery Reconditioning: YOU NEVER KNEW IT COULD BE THIS EASY

Battery Reconditioning: YOU NEVER KNEW IT COULD BE THIS EASY

How to recondition  your used batteries to make them as good as new.

Use a needle and discard it, use your pen and toss it into the trash can, even your shopping bags can find their way to the incinerators very easily, but not your car batteries; they should not be treated like used diapers.

Specifically known as the lead acid battery, your car battery is essentially rechargeable. It obviously does not come with a charging cord but it gets recharged by the alternator of your vehicle while you’re driving.

Lead acid batteries are actually of two types: the flooded cell and the sealed cell. The flooded cell batteries have detached caps and therefore needs to be occasionally checked for water levels while the seal batteries need no maintenance. The good news is car battery reconditioning can be done by almost anyone and can be done for any kind of car battery. You’ve probably had the disappointing experience when you’re already late for work and you hop into your car just to see that your battery gives an awful tkkk tkkk sound instead of roaring fully to life. Many a time,car batteries fail when we least expect them to. The next time your battery gives you that disappointing experience, just hold your cool because you’re about to learn how to wake it from it’s suicide.fix broken batteries

Reconditioning batteries is very simple and easy and everyone can do it. All you need is time and a few gadgets and there you go, your battery becomes as good as new. Your old battery will function the same way and will have the same features of a brand new one.

You’re just about to learn the most important information in your car maintenance history, just pay attention to the details of the processes I’m about to expose to you

Knowing how to recondition your batteries will have a positive effect on the environment and help save our planet in general. At the same time, you will also save some money and you will be able to extend your battery life. On the other side, all these procedures are very simple.

This guide is for Led acid batteries if you would like to recondition any other battery or you would like a way more in depth tutorial I highly recommend looking at this guide here>>>>> Click Here!

PLEASE DON’T TRY THIS AT HOME UNLESS YOU KNOW EXACTLY WHAT YOU ARE DOING AND YOU TAKE ALL THE NECESSARY PRECAUTIONS. Instead I highly recommend reading this book until you have the necessary knowledge >>>Battery Reconditioning 

OK, let’s get started!

Safety first

  • Always wear proper eye, face and hand protection
  • Keep all sparks, flames, cigarettes, or anything that could cause an explosion, away from the battery
  • Make sure the work area is well ventilated
  • Never attempt to lean over the battery while it is boosting, testing or charging.

You also need to inspect batteries for any defects like

  • Melted plastic housing
  • Warped battery sides
  • Burnt disconnectors
  • Badly damaged plates inside

If no visible signs of damage are present, the most likely your battery can be restored.

First you need to TEST YOUR BATTERY

It needs to register 12 volts on a voltmeter. If it’s between 10 and 12 volts, you may be able to restore your battery to its full function, but if it’s less than 10 volts, you’re probably wasting your time.Recondition car battery

Next you need to remove the battery cell caps

Remove the battery cell covers by prying them off with a screw driver, taking care not to allow anything to fall down into the cells.

With a damp paper towel, carefully clean the area immediately around the open holes.

Make sure you drain any fluid out of the battery

Next, we’re going to need a solution of distilled water and Epsom salt. It can be prepared by

Heating half a liter of distilled water up to 65oC and pouring half a kilogram of the salt into warm water. Ensure that it is completely dissolve.

DO NOT USE REGULAR WATER. This would make things worse because it contains minerals that can corrode your battery.

Next, you have to FILL EACH CELL OF THE BATTERY WITH THE EPSOM SALT SOLUTION. This should be done with the use of a plastic funnel to fill it properly, making sure the visible lead plates inside are completely covered.

Place the battery caps back on and shake the battery well in order to ensure that the Epsom salt solution is well distributed inside the cells.

The next thing is to recharge the battery

You need to attach the battery charger to the terminals and allow the battery to charge for 24 hours. Depending on the condition of the battery, repeating this process two or three times can substantially increase battery’s performance.

In order to discharge, reconnect it to the terminals on the car and turn on the headlights. When you observe that the lights begin to dim, disconnect your battery and recharge as described above.

There you go, your flooded led acid battery is now as good as new! Go and try it, then come back to read more expository guides that will save your more time and money.

If you are not an expert in electronics or want to recondition other types of batteries I highly recommend looking at this guide it breaks down how to recondition all types of batteries, whether you just want to repair your old electronics or you are looking to reconditions batteries for profit this is the guide for repair laptop batteryyou.>>>> Click Here!

 

About